Safety Ratings
2004 Chevrolet Malibu
Front Crash Driver Side 4.0000
Front Crash Passenger Side 4.0000
Side Crash Driver Side 4.0000
Side Crash Passenger Side 5.0000
Number of Recalls5
Number of Complaints1101
Number of Investigations4
Recall Notice

LemonFree has found some important recall information regarding 2004 Chevrolet Malibu vehicles

2004 Chevrolet Malibu (2/28/2011)  

Campaign Number: 11E009000

Component Name: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Manufacturer: General Motors LLC

Description: TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.

Defect: A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.

Corrective Action: TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.

2004 Chevrolet Malibu (4/7/2009)  

Campaign Number: 09E012000

Component Name: EXTERIOR LIGHTING

Manufacturer: General Motors LLC

Description: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Defect: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Action: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

2004 Chevrolet Malibu (4/19/2004)  

Campaign Number: 04V190000

Component Name: SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE

Manufacturer: General Motors LLC

Description: SOME OF THESE PASSENGER VEHICLES HAVE AN ELECTRONIC CONTROL UNIT (ECU) THAT MAY CALCULATE A HIGHER THAN ACTUAL VEHICLE SPEED BECAUSE OF AN ERRATIC REAR-WHEEL SPEED SENSOR SIGNAL, AND CAUSE ABS ACTIVATION WHERE IT IS NOT NEEDED OR NEEDED ABS ACTIVATION TO BE EXTENDED DURING BRAKING AS THE VEHICLE SPEED DROPS TO ABOUT 3 MPH.

Defect: UNEXPECTED ABS ACTIVIATION COULD INCREASE STOPPING DISTANCE UP TO ABOUT 11 FEET DPENDING ON THE GRADE OF THE ROAD, INCREASING THE RISK OF A CRASH.

Corrective Action: DEALERS WILL REPROGRAM THE ABS CONTROLLER. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.

2004 Chevrolet Malibu (4/16/2004)  

Campaign Number: 04V188000

Component Name: SEAT BELTS:FRONT:ANCHORAGE

Manufacturer: General Motors LLC

Description: ON CERTAIN PASSENGER VEHICLES, ANALYSIS OF AN A SIDE IMPACT CRASH TEST CONDUCTED BY THE NHTSA;S NEW CAR ASSESSMENT PROGRAM (NCAP) INDICATED THAT THE OUTBOARD ANCHORAGE OF THE DRIVER'S SEAT BELT COULD DISCONNECT BECAUSE OF CONTACT BETWEEN THE SEAT TRIM AND THE ANCHORAGE CONNECTOR WHEN THE SEAT WAS ADJUSTED TO ITS LOWEST POSITION.

Defect: IF THIS OCCURRED IN A CRASH, THE DRIVER COULD RECEIVE GREATER INJURIES.

Corrective Action: DEALERS WILL INSERT A RETAINER ON BOTH THE DRIVER'S AND PASSENGER'S BELT ANCHORAGES. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.

2004 Chevrolet Malibu (2/24/2004)  

Campaign Number: 04V094000

Component Name: EQUIPMENT:OTHER:LABELS

Manufacturer: General Motors LLC

Description: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES THAT WERE NOT EQUIPPED WITH AN ADVANCED OCCUPANT RESTRAINT SYSTEM (AORS) HAVE DRIVER AND PASSENGER SIDE SUN VISORS WITH AORS LABELS. THE AORS LABELS DO NOT INCLUDE STATEMENTS AND THE ILLUSTRATION REQUIRED BY FMVSS NO. 208 FOR VEHICLES WITHOUT AORS.

Defect:

Corrective Action: OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.

2004 CHEVROLET MALIBU LT for sale

Displaying 1-16 of 164

2004 Chevrolet Malibu LT

$9,763

2004 CHEVROLET MALIBU LT

  • Bodystyle: Sedan
  • Mileage: 58284 Miles
  • Ext Color: Silver
  • Int Color: N/A
  • Trans: Automatic
  • Engine: 6 Cyl
  • Drive: FWD
  • Location: Santa Maria, CA
  • MPG: 20 City / 29 Hwy

2004 Chevrolet Malibu LT

$6,691

2004 CHEVROLET MALIBU LT

  • Bodystyle: Sedan
  • Mileage: 96370 Miles
  • Ext Color: Gray
  • Int Color: Gray
  • Trans: Automatic
  • Engine: 6 Cyl
  • Drive: FWD
  • Location: Baltimore, MD
  • MPG: 20 City / 29 Hwy

2004 Chevrolet Malibu LT

$6,991

2004 CHEVROLET MALIBU LT

  • Bodystyle: Sedan
  • Mileage: 85096 Miles
  • Ext Color: Silver
  • Int Color: Tan
  • Trans: Automatic
  • Engine: 6 Cyl
  • Drive: FWD
  • Location: North Canton, OH
  • MPG: 20 City / 29 Hwy

2004 Chevrolet Malibu LT

New Listing
$9,998

2004 CHEVROLET MALIBU LT

  • Bodystyle: Sedan
  • Mileage: 99699 Miles
  • Ext Color: White
  • Int Color: N/A
  • Trans: Automatic
  • Engine: 6 Cyl
  • Drive: FWD
  • Location: Houston, TX
  • MPG: 20 City / 29 Hwy

2004 Chevrolet Malibu LT

New Listing
$6,899

2004 CHEVROLET MALIBU LT

  • Bodystyle: Sedan
  • Mileage: 106081 Miles
  • Ext Color: Gray
  • Int Color: N/A
  • Trans: Automatic
  • Engine: 6 Cyl
  • Drive: FWD
  • Location: Auburn, WA
  • MPG: 20 City / 29 Hwy

2004 Chevrolet Malibu LT

$7,100

2004 CHEVROLET MALIBU LT

  • Bodystyle: Sedan
  • Mileage: N/A
  • Ext Color: Gray
  • Int Color: N/A
  • Trans: Automatic
  • Engine: 6 Cyl
  • Drive: FWD
  • Location: Cambridge, OH
  • MPG: 20 City / 29 Hwy

2004 Chevrolet Malibu LT

New Listing
$7,012

2004 CHEVROLET MALIBU LT

  • Bodystyle: Sedan
  • Mileage: 89200 Miles
  • Ext Color: Black
  • Int Color: N/A
  • Trans: Automatic
  • Engine: 6 Cyl
  • Drive: FWD
  • Location: Milwaukee, WI
  • MPG: 20 City / 29 Hwy

2004 Chevrolet Malibu LT

$7,490

2004 CHEVROLET MALIBU LT

  • Bodystyle: Sedan
  • Mileage: 118871 Miles
  • Ext Color: Gray
  • Int Color: Tan
  • Trans: Automatic
  • Engine: 6 Cyl
  • Drive: FWD
  • Location: Tacoma, WA
  • MPG: 20 City / 29 Hwy

2004 Chevrolet Malibu LT

$8,495

2004 CHEVROLET MALIBU LT

  • Bodystyle: Sedan
  • Mileage: 51369 Miles
  • Ext Color: Black
  • Int Color: Gray
  • Trans: Automatic
  • Engine: 6 Cyl
  • Drive: FWD
  • Location: Oak Lawn, IL
  • MPG: 20 City / 29 Hwy

2004 Chevrolet Malibu LT

New Listing
$6,988

2004 CHEVROLET MALIBU LT

  • Bodystyle: Sedan
  • Mileage: 74590 Miles
  • Ext Color: Blue
  • Int Color: N/A
  • Trans: Automatic
  • Engine: 6 Cyl
  • Drive: FWD
  • Location: Fort Wayne, IN
  • MPG: 20 City / 29 Hwy

2004 Chevrolet Malibu LT

Contact Dealer For Pricing

2004 CHEVROLET MALIBU LT

  • Bodystyle: Sedan
  • Mileage: 117000 Miles
  • Ext Color: N/A
  • Int Color: N/A
  • Trans: Automatic
  • Engine: 6 Cyl
  • Drive: FWD
  • Location: Bardstown, KY
  • MPG: 20 City / 29 Hwy

2004 Chevrolet Malibu LT

$8,000

2004 CHEVROLET MALIBU LT

  • Bodystyle: Sedan
  • Mileage: 76248 Miles
  • Ext Color: Red
  • Int Color: N/A
  • Trans: Automatic
  • Engine: 6 Cyl
  • Drive: FWD
  • Location: Peoria, IL
  • MPG: 20 City / 29 Hwy

2004 Chevrolet Malibu LT

$5,995

2004 CHEVROLET MALIBU LT

  • Bodystyle: Sedan
  • Mileage: 98709 Miles
  • Ext Color: Red
  • Int Color: Tan
  • Trans: Automatic
  • Engine: 6 Cyl
  • Drive: FWD
  • Location: Hackettstown, NJ
  • MPG: 20 City / 29 Hwy

2004 Chevrolet Malibu LT

$4,995

2004 CHEVROLET MALIBU LT

  • Bodystyle: Sedan
  • Mileage: 133535 Miles
  • Ext Color: Gray
  • Int Color: Gray
  • Trans: Automatic
  • Engine: 6 Cyl
  • Drive: FWD
  • Location: Northumberland, PA
  • MPG: 20 City / 29 Hwy

2004 Chevrolet Malibu LT

$3,970

2004 CHEVROLET MALIBU LT

  • Bodystyle: Sedan
  • Mileage: 136792 Miles
  • Ext Color: White
  • Int Color: Tan
  • Trans: Automatic
  • Engine: 6 Cyl
  • Drive: FWD
  • Location: Mentor, OH
  • MPG: 20 City / 29 Hwy
FEEDBACK